你好,歡迎來到濟南濟柴環能燃氣發電設備有限公司官方網站!

你在選擇沼氣發電機組的時候注意了嗎?

來源:http://www.juhua522848.cn   發布于:2018-04-20

1.大功率沼氣發電設備購買成本高,非常高!

1. high power biogas power generation equipment purchase cost is high, very high!

2.大功率的沼氣發電設備運行要求很高:沼氣要充足,成分要穩定,脫硫脫水要迅速且充分(大發電機組耗氣量大,進氣流量快,若脫硫不迅速充分,硫就會進入發動機,損壞發動機氣門、缸頭、火花塞等部件),在現有條件下我們很難滿足大發電機組每小時幾十立方沼氣消耗量的脫硫問題(脫硫速度比進入發電機組的沼氣流速慢很多),即使能滿足,成本也會大幅上升。

2. high power biogas generating equipment have high operation requirements: sufficient methane, stable composition, rapid and full desulfurization and dewatering (large generating units, fast intake flow, and fast desulphurization, sulfur will enter the engine, damage engine valve, cylinder head, spark plug and so on), under the existing conditions. It is difficult to meet the desulfurization of dozens of cubic methane consumption per hour for large generating units. (the speed of desulfurization is much slower than that of the generator's biogas). Even if it is satisfied, the cost will rise significantly.

QQ截圖20171025151837.jpg

所以我們經常會看到:1.買的便宜的沼氣發電機組不好用,隻能當擺設;貴的發電機又買不起,沼氣産生不了經濟效益,隻能白白排掉,這樣又形成了二次污染;2.裝配了大型沼氣發電設備的業主,三天兩頭的沼氣發電機組就出故障了,總是在壞,無法正常使用。主要原因是大的沼氣發電機組耗氣量大,我們又無法高效的對沼氣進行脫硫脫水處理,不合格的沼氣進入發電機組導緻故障率超級高。

So we often see: 1. bought cheap biogas generator is not good to use, can only be set up; expensive generator can not afford to buy, biogas can not produce economic benefits, can only be discharged in white, so the formation of two pollution; 2. assembly of large biogas power plant owners, three days and two of the biogas generator set out Failure, always in the bad, can not be used normally. The main reason is that the large amount of gas consumption of the large methane generating set is large, and we can not efficiently remove the methane from the biogas, and the unqualified methane into the generating unit leads to the super high failure rate.

真正科學合理的選配沼氣發電機組,應該是根據沼氣池的産氣量、脫硫脫水處理的速度等因素來選配沼氣發電機。由于沼氣池産氣是慢慢進行的,每小時的産氣量有限,流量也有限,沼氣脫硫脫水也需要時間,因此每小時使用的沼氣是有限的。

The truly scientific and rational selection of biogas generating units should be based on biogas production capacity, desulphurization and dehydration treatment speed and other factors to select biogas generators. As the biogas production of the biogas pool is carried out slowly, the volume of gas production per hour is limited, the flow is limited, and the biogas desulfurization and dehydration also take time, so the biogas used per hour is limited.

我們專門為您提供沼氣發電機組,想要了解更多的資訊内容,歡迎訪問我們的網站:http://www.juhua522848.cn專業的知識為您提供貼心的服務。

We specialize in providing you with the biogas generator set, want to know more information content, welcome to our website: http://www.juhua522848.cn professional knowledge for you to provide intimate service.


上一篇:靜音箱式發電機的是怎麼設計的?
下一篇:影響柴油發電機價格與哪些因素有關?

http://m.juhua522848.cn|http://wap.juhua522848.cn|http://www.juhua522848.cn||http://juhua522848.cn